Installer: Please leave this manual with the appliance owner for future reference 200-0165 Feb 2007 7116 Beatty Dr Mission, BC V2V 6B4 Canada WARNIN
Optima 32 - 1 10 LEVELING THE OPTIMA 32-1 DIRECT VENT INSERT Before placing the appliance into the fireplace, check the hearth of the fireplace to
Optima 32 - 1 11 The Optima 32 Requires two Flexible gas flue liners Flue Collar (inlet) - 3” (76 mm) diameter Flue Collar (outlet) - 3” (76 mm)
Optima 32 - 1 12 Instructions for use with Archgard vertical termination cap. Part # TK-40/32. Install the termination cap being sure to provided suf
Optima 32 - 1 13 SURROUND INSTALLATION Make sure the gas and electrical lines are properly connected to the appliance. Slide the unit into the fir
Optima 32 - 1 14 If a wall-mounted switch or a wall-mounted thermostat is desired, Archgard recommends that the device be wired as shown in Fig 1. Th
Optima 32 - 1 15 LOG PLACEMENT NOTE: Installing the “FiberFlame” Ceramic logs in any other position other than shown will result in flame impingeme
Optima 32 - 1 16 LOG PLACEMENT... Continued Step 1. Locate Log with 12 stamped on the bottom and place it on the log rest as shown. Step 2. Locate Lo
Optima 32 - 1 17 LOG PLACEMENT... Continued Step 3. Locate Log with 74 stamped on the bottom and place it on the ember bed as shown. Step 4. Locate L
Optima 32 - 1 18 Step 5. Locate Log with 82 stamped on the bottom and place as shown. Step 6. Locate Log with 83 stamped on the bottom and place as s
Optima 32 - 1 19 The Optima 32-1 comes with a set of Ceramic Brick Panels. They are factory installed for your convenience, therefore no adjustments
Optima 32 - 1 20 INITIAL OPERATION 1. Check that the appliance is properly vented and connected to the gas supply. 2. Check that the logs and branc
Optima 32 - 1 21 This appliance has a pilot which must be ignited using the sparker located next to the appliance valve controls. When lighting the p
Optima 32 - 1 22 1. Set the thermostat to the lowest setting and turn the remote switch to “OFF”. 2. Turn off all electric power to the appliance i
Optima 32 - 1 23 GLASS DOOR REMOVAL CAUTION: Do not attempt to remove the glass door when the appliance is hot. 1. Remove the TOP louver by pulling
Optima 32 - 1 24 OPTIONAL BAY DOOR INSTALLATION CAUTION: Only Trim kit (s) supplied by the manufacturer shall be used in the installation of this ap
Optima 32 - 1 25 TROUBLESHOOTING SYMPTOM ACTION Pilot will not light after pressing the sparker many times. 1. When lighting the appliance for the f
Optima 32 - 1 26 TROUBLESHOOTING Cont... SYMPTOM ACTION The main burner does not turn on with the pilot lit. Cont... 3. Check to make sure the therm
Optima 32 - 1 27 Regularly: • Frequent cleaning of the ceramic glass is required. Archgard recommends using a good quality “gas fireplace” glass cl
Optima 32 - 1 28 Before servicing, read the terms and conditions of the Archgard warranty at the back of the manual. Contact the authorized Archgard
Optima 32 - 1 29 ADJUSTING PRIMARY AIR NOTE: Fig. 1. Is to give an example of what is a correct or incorrect flame pattern. It is not a true represen
INTRODUCTION Congratulations on choosing an Archgard Gas Fireplace! The Optima 32-1 Direct Vent Insert is one of the most advanced Direct Vent Insert
Optima 32 - 1 30 1. Open the lower grills. 2. The pressure test taps are located on the valve. The taps are located in the gas valve front face. Th
Optima 32 - 1 31 REPLACING CONVECTION BLOWER Caution: Label all wires prior to disconnection when servicing controls. Wiring errors can cause imprope
Optima 32 - 1 32 Item # Item Description Qty Unit A 308-0091 Valve HONEYWELL Hi/Low Natural Gas 1 EA B 308-0101 Replacement Piezo (comes p
Optima 32 - 1 33 PARTS LIST - FiberFlame Logs and Burner Bed Item # Item Description Qty Unit 310-0080 FiberFlame Log 80 1 EA 310-0074 FiberFl
Optima 32 - 1 34 REPLACEMENT PARTS LIST ARCHGARD OPTIMA 32-1 Item # Item Description Qty Unit 200-0165 Owners Manual 1 EA 832-0005 Top Louver
Optima 32 - 1 35 REPLACEMENT PARTS LIST ARCHGARD OPTIMA 32-1 Item # Item Description Qty Unit Replacement parts for BBAY-32 Bay Door 300-0031
This Limited Warranty is made by ARCHGARD INDUSTRIES LTD., hereinafter referred to as “Archgard”. Archgard warrants to the original purchaser of an
Optima 32 - 1 37 FREQUENTLY ASKED QUESTIONS Listed below are some frequently asked questions regarding Archgard Gas Fireplaces. If you have ques-tion
Optima 32 - 1 38 NOTES
POSTAGE FOLD DOWN AT LINE FOLD DOWN AT LINE & TAPE CLOSED CUT ALONG LINE CUT ALONG LINE CUT ALONG LINE WARRANTY REGISTRATION ARCHGARD INDUSTRIES
CONTENTS CONTENTS PAGE # Caution and Safety Instructions 5 Appliance Certification, Installation Codes and Specifications 6 Appliance Dimensions an
Archgard Industries Ltd. 7116 B ea t t y Dr iv e Mission, B.C. V2V 6B4 Canada Website: www.archgard.com
Optima 32 - 1 5 Due to high temperatures, the appliance should be located out of traffic and away from furniture and draperies. Children and adults
Optima 32 - 1 6 This appliance is tested and certified to the following USA and Canadian gas appliance standards. - ANSI Z21.88b-2003 / CSA 2.33b-20
Optima 32 - 1 7 MINIMUM FIREPLACE DIMENSIONS J SIDE VIEW TOP VIEW L M K APPLIANCE DIMENSIONS DIMENSIONS A 25-5/8” (651 mm) B 16” (406 mm) C
Optima 32 - 1 8 CLEARANCES TO COMBUSTIBLES TOP VIEW SIDE VIEW Clearances to Faceplate 1” (25 mm) 1” (25 mm) Sidewalls or Mantle Supports CAUTION: Th
Optima 32 - 1 9 Before connecting the appliance to the gas supply line, double check that the appliance you have purchased is designed for the gas ty
Comments to this Manuals