Archgard Optima 45 - 3 Specifications

200-0242 MAY 2007 Users’ Installation Operation and Maintenance Manual 7116 Beatty Dr Mission, BC V2V 6B4 Canada OPTIMA PS1OPTIMA PS1 Pellet Stove

OPTIMA PS1 PELLET STOVE 10 10 RESIDENTIAL & MOBILE HOME INSTALLATION MINMUM CLEARANCES TO COMBUSTIBLE MATERIALS SIDEWALL A - 229 mm / 9”

OPTIMA PS1 PELLET STOVE 11 11 COMBUSTION AIR SUPPLY Fresh outside air is not required for normal residential installation. The stove consumes oxy

OPTIMA PS1 PELLET STOVE 12 12 VENTING Use only listed type L, PL or other suitable listed vents for pellet fuel burning stoves. Install venting sy

OPTIMA PS1 PELLET STOVE 13 13 A= Clearance above grade, veranda, porch, deck, or balcony 12 inches (30 cm) J= Clearance to non-mec

OPTIMA PS1 PELLET STOVE 14 14 TYPICAL VENTING CONFIGURATIONS: HORIZONTAL VENTING NOTE: Horizontal venting with vertical offset is preferred. The a

OPTIMA PS1 PELLET STOVE 15 15 VERTICAL VENTING

OPTIMA PS1 PELLET STOVE 16 16 VENTING INTO FIREPLACE OR CHIMNEY Make sure the chimney top is properly sealed to prevent the intrusion of weather wi

OPTIMA PS1 PELLET STOVE 17 17 ADDITIONAL MOBILE HOME INSTALLATION REQUIREMENTS: In addition to standard installation instructions, the following r

OPTIMA PS1 PELLET STOVE 18 18 OPERATING SAFETY PRECAUTIONS • Hot while in operation. Contact may cause skin burns. Keep children, pets, clothin

OPTIMA PS1 PELLET STOVE 19 19 OPERATING INSTRUCTIONS Check List Before Starting Your Pellet Stove: • Check that the pellet stove is properly plu

OPTIMA PS1 PELLET STOVE 2 2 Congratulations on choosing a state-of-the-art Archgard Hearth Product! The hand crafted Optima PS1 has been designed

OPTIMA PS1 PELLET STOVE 20 20 FILLING THE HOPPER WITH PELLET FUEL: Open the hopper lid by placing your fingers in the recessed handle on the hoppe

OPTIMA PS1 PELLET STOVE 21 21 CONTROLS FUNCTIONS:

OPTIMA PS1 PELLET STOVE 22 22 THERMOSTAT / MANUAL Switch: Selects the pellet stove operating mode. Slide the switch to MANUAL (the far right posit

OPTIMA PS1 PELLET STOVE 23 23 FAN HIGH Button: Use this button to override the automatic fan speed control and turn the convection fan on high. Th

OPTIMA PS1 PELLET STOVE 24 24 START-UP INSTRUCTIONS When first operating the pellet stove, switch it to the MANUAL mode, so you can have full cont

OPTIMA PS1 PELLET STOVE 25 25 FINE TUNING THE BURNING OF PELLET FUEL Combustion Air Shutter: The combustion air to the burn pot is controlled by t

OPTIMA PS1 PELLET STOVE 26 26 FINE TUNING THE BURNING OF PELLET FUEL (Cont…) Fuel Quality: Although there are standards for pellet fuel, fuel qual

OPTIMA PS1 PELLET STOVE 27 27 MAINTENANCE • REGULAR MAINTENANCE MUST BE CONDUCTED FOR SAFE AND EFFICIENT OPERATION OF THE STOVE. • CONDUCT MAINTE

OPTIMA PS1 PELLET STOVE 28 28 WITH THE DOOR OPENED ASH CLEAN-OUT SLIDER ASH DRAWER Every ton of pellet fuel burned or 6 months: Disconnect power t

OPTIMA PS1 PELLET STOVE 29 29 MISCELLANEOUS MAINTENANCE: DOOR GLASS BREAKAGE See your dealer for the exact replacement of door assembly. The owner

OPTIMA PS1 PELLET STOVE 3 3 Important Safety Notes 4 Rating Plate Label 6 Specifications 7 Dimensions 8 INSTALLATION METHODS Important Installati

OPTIMA PS1 PELLET STOVE 30 30 DANGER: RISK OF ELECTRICAL SHOCK. DISCONNECT POWER BEFORE SERVICING STOVE. CAUTION: MOVING PARTS MAY CAUSE INJURY. H

OPTIMA PS1 PELLET STOVE 31 31 LEFT SIDE WITH SERVICE PANEL REMOVED RIGHT SIDE WITH SERVICE PANEL REMOVED COMPONENT LOCATIONS PROOF OF FIRE SWITCH

OPTIMA PS1 PELLET STOVE 32 32 PROBLEM CAUSE CURE Stove Will Not Start. Make sure the hopper lid is closed flat so as to contact the auger interl

OPTIMA PS1 PELLET STOVE 33 33 PROBLEM CAUSE CURE Stove Will Not Start. (Cont…) 9. Tripped or defective over temperature switch. Press the red

OPTIMA PS1 PELLET STOVE 34 34 PROBLEM CAUSE CURE Glass is Dirty (A light white/tan accumulation is normal) 1. Need more combustion air. Push

OPTIMA PS1 PELLET STOVE 35 35 PARTS LIST FOR OPTIMA PS1 NUMBER PART NO. DESCRIPTION PS1-FS FREESTANDING OPTIMA PS1 PELLET STOVE STANDARD (ALL OTHE

OPTIMA PS1 PELLET STOVE 36 36 This Limited Warranty is made by ARCHGARD INDUSTRIES LTD., hereinafter referred to as “Archgard”. Archgard warr

OPTIMA PS1 PELLET STOVE 37 37 WARRANTY LIMITATION: THIS LIMITED WARRANTY IS MADE IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED AS TO Q

POSTAGE WARRANTY REGISTRATION ARCHGARD INDUSTRIES LTD. 7116 BEATT Y DRIVE MISSION, B.C. CANADA V2V 6B4 FOLD DOWN AT LINE FOLD DOWN AT LINE & TAPE

Archgard Industries Ltd. 7116 B e a t t y D r i v e Mission, B.C. V2V 6B4 Canada Website: www.archgard.com

OPTIMA PS1 PELLET STOVE 4 4 IMPORTANT SAFETY NOTES • When installing your stove, particular attention should be paid to fire protection. If this

Fireplace Model Number: OPTIMA PS1 Serial Number: Date of Installation: Dealer’s Name & Address: Dealer’s Phone Number:

OPTIMA PS1 PELLET STOVE 5 5 SAFETY NOTE: If this stove is not properly installed, a house fire may result. For your safety, follow the installation

OPTIMA PS1 PELLET STOVE 6 6 CAUTION • HOT WHILE IN OPERATION. • DO NOT TOUCH, KEEP CHILDREN, CLOTHING AND FURNITURE AWAY. • CONTACT MAY CAUSE S

OPTIMA PS1 PELLET STOVE 7 7 SPECIFICATIONS MODEL OPTIMA PS1 FREESTANDING Pellet Stove DEPTH 28” (711 mm) HEIGHT 32.5” (826 mm) E.P.A. EMISSIONS

OPTIMA PS1 PELLET STOVE 8 8 DIMENSIONS (661mm) (820mm) (820mm) (712mm) (597mm) (51mm) (90mm) (77mm) (712mm) (267mm) (369mm) (597mm) (661mm)

OPTIMA PS1 PELLET STOVE 9 9 INSTALLATION INSTRUCTIONS IMPORTANT INSTALLATION NOTES: • Please read this entire manual before you install and use